This video will show you how to replace the passenger side split axle shaft typically found on Toyota passenger cars (i.e., Camry, Avalon, Highlander, ES300, ES330 & ES350). The customer had been complaining about wheel vibration coming from the passenger side front end after driving into a large pot hole. The wheel was not bent and the tires were found not to be damaged, out of round or balance. However, with both front wheels off the ground, the engine running and the car's transmission positioned in drive, axle wobbling in and out of its outer cv housing was visible. Either the axle was bent or the internal bearings or bearing cage were damaged from the pot hole experience.
Toyota's passenger side axle shaft design is consistent for the majority of their front wheel drive vehicles; therefore this procedure can be used on many of Toyota's vehicles. A 12 point 30 mm nut is used to secure the axle to the wheel hub. A 6 point 30 mm socket will not work as a substitute on this type of nut. Depending on the environment where the car resides (road salt in winter & moisture) will determine the ease with which the axle's splines will slide out of the wheel hub. Corrosion buildup between the axle splines and the wheel hub is typical and may require hammering the shaft end to force the splines loose from the wheel hub with either a heavy duty punch tool or a powered jack hammer. The center half shaft bearing support hanger is braced and bolted onto the engine block. This bearing is held in place by a 12 mm bolt and a large snap ring. The snap ring's protruding ears can be pinched using long needle nose pliers to move the ring out of its support groove. Afterwards, the center bearing can be removed from its support hanger using a long punch tool and hammer. The tip of the punch tool should be braced against inner cv joint housing. A series of hammer blows to the punch should slowly work out the center bearing from it support hanger.
If you'd like to make a donation to the channel, please follow the link below: https://paypal.me/HardlyMoving?locale...
Parts & Specialty Tools:
Castrol Transmax ATF/CVT Full Synthetic Universal Automatic Transmission Fluid, 1 Gallon
https://amzn.to/3vjIjll
Milwaukee M18 FUEL 18Volt LithiumIon Cordless 1/2 in. High Torque Impact Wrench w/Friction Ring (1,400 lbs Torque!)
https://amzn.to/2NUtBhp
Milwaukee 48111850 M18 Redlithium 5.0Ah Bat Pack
https://amzn.to/3sEQST7
Milwaukee M12 & M18 Replacement Battery Charger
https://amzn.to/3827MmR
Axle Nut Socket, 30 mm, 1/2 in Drive, 12 Point
https://amzn.to/2OLgbly
Axle Nut Socket, 32 mm, 1/2 in Drive, 6 point Deep
https://amzn.to/2rby1F5
Long Reach Needle Nose Pliers
https://amzn.to/2OLoU73
Toyota Sienna 1998 thru 2006 (Haynes Repair Manual)
https://amzn.to/3iXPXbF
Snap Ring Pliers
https://amzn.to/2qJPRyt
Cardone CV Half Shaft Assembly (with 3.0L V6 engine)
LEXUS ES300 19972001
TOYOTA AVALON 19972004
TOYOTA CAMRY 19972001
TOYOTA SIENNA 19982003
TOYOTA SOLARA 19992003
https://amzn.to/2LkFHvH
LEXUS ES300 20022003
LEXUS ES330 20042006
LEXUS ES350 20072012
LEXUS RX330 20042006
LEXUS RX350 20072009
TOYOTA AVALON 20052016
TOYOTA CAMRY 20022017
TOYOTA HIGHLANDER 20042007
TOYOTA SOLAR 20042008
https://amzn.to/2P6z4hL
If the axle cv bearings, cage and shaft are not damaged, you can reboot and grease your existing cv axle:
Outer CV Replacement Boot
LEXUS ES300 19972001
LEXUS RX330 20042006
LEXUS RX350 20072009
TOYOTA AVALO 19982002
TOYOTA CAMRY 19972001
TOYOTA COROLLA 20092010
TOYOTA HIGHLANDER 20102013
TOYOTA MATRIX 20092013
TOYOTA SIENNA 19982002
TOYOTA SOLAR 19992002
https://amzn.to/2DOtHhR
Outer CV Replacement Boot
TOYOTA AVALON 20032004
TOYOTA CAMRY 20022006
TOYOTA COROLLA 20052006
TOYOTA HIGHLANDER 20032007
TOYOTA MATRIX 20032006
TOYOTA RAV4 20032005
TOYOTA SIENNA 20032006
TOYOTA SOLARA 20022006
https://amzn.to/2rVsjaH
Outer CV Replacement Boot
LEXUS ES350 20072018
LEXUS HS250H 20102012
LEXUS NX200T 20152017
LEXUS NX300 2018
LEXUS RX300 19992003
LEXUS RX330 20042006
LEXUS RX350 20072009
TOYOTA AVALON 20052018
TOYOTA CAMRY 20082009
TOYOTA CELICA 19992005
TOYOTA HIGHLANDER 20012013
TOYOTA PRIUS 2010
TOYOTA RAV4 19962018
TOYOTA SIENNA 20072010
https://amzn.to/2PhdeYT
As an Amazon associate, I earn from qualifying purchases. Thank you for your support!
Please Subscribe: https://goo.gl/x6fySQ
#toyotacvaxle